How stupid is this?

Salty

Salty

Touchdown! Greaser!
PoA Supporter
Joined
Dec 21, 2016
Messages
14,264
Location
FL
Display Name
Display name:
Salty
You fly your R44 as close to the pump as you can. Leave the engine running, Swipe your card, climb up on the side and fuel it up with nobody inside and the rotor spinning merrily around (not slowing down). This seems incredibly irresponsible to me. I wish I’d have taken a pic, but I didn’t.

Over reaction?
 
Last edited:
I won't refuel a running lawnmower, so I sure wouldn't with a chopper. :eek2:
 
R44 burns Avgas, right?

Wouldn’t be my first choice.

Probably some dude who thinks because the military hot pumps it’s therefore ok for him to do it.
 
Yeah that's pretty stupid. We hot pump all the time, but the pilots stay at the controls and the ground crew is trained for it. That's a helluva big difference from what you're describing for that R44.
 
I would think grounding (electrical) would matter a lot with the blades spinning. Seems stupid to me, but I haven't stayed in a Holiday Inn Express in a really long time.
 
When we hot pump Navy helos, we fill with JP-5 using a pressure nozzle (no open vapors) and there is always at least one pilot at the controls.

I can’t imagine pumping AVGAS into a running helicopter with a typical self-serve pump nozzle. Not my idea of a good time.
 
Sounds like a Darwin Award candidate that unfortunately could hurt others as well. What a moron.
 
Salty said:
This seems incredibly irresponsible to me.
Click to expand...
Salty said:
Over reaction?
Click to expand...
FYI: this has been a topic of intense discussion in the helicopter world for decades... which I tend to stay out of. But a pilot performing an unassisted hot refuel in a avgas Robbie, at an airport no less, pushes that debate toward the stupid end....
 
Yeah I wouldn’t do that with my personal helicopter, or airplane for that matter. But his aircraft and as long as nothing in the RFM or local ordinance prohibiting it, oh well.

I suppose rapid or “hot” refuel is done more on helos. Probably done it a thousand times but with proper procedures / safe guards in place. Good example of rapid refuel using gravity feed below. As stated above, military is generally pressure or closed circuit. Gravity would take waaay too long.

 
Hot refueling is done all the time. I saw the Stat MedVac helicopters at my airport refueling with blades turning all the time with only one guy . Friction on on both collective and cyclic controls and other precautions. May be more appropriate in turbines because start cycles are hard on turbines ? Don't know about Piston engines. 100 LL is sure more flammable than Jet A
But its an approved procedure
 
I doubt it’s “approved” for a single person to perform with no ground crew. Might not be illegal, but I seriously doubt it’s “approved”.

https://www.faa.gov/other_visit/avi...afety/safo/all_safos/media/2010/SAFO10020.pdf


An appropriately certificated and rated pilot should be at the flight controls during the entire hot fueling/loading process with controls appropriately adjusted to prevent aircraft movement.
Click to expand...
At least two ground personnel should be present during hot fueling/loading. One person conducts the fueling/loading, while the other stands by prepared to activate the fuel/chemical emergency shutoff and handle fire extinguishers if necessary. The aircraft should remain well clear of the fuel source, and at no time should the aircraft wing or helicopter blades extend over the fueling source
Click to expand...
 
Last edited:
Well I didn't mean FAR or something like that but the helicopter websites are full of people stating they do it all the time and its part of their company procedures. Are you a Bell guy ?Then you probably know more than me about this stuff.
 
blueskyMD said:
Well I didn't mean FAR or something like that
Click to expand...
Well when you use the word "approved" that is the normal implication. As I mentioned above, a pilot exiting his helicopter while it continues to run is hotly debated every year. Are there actual approved procedures, sure, but mostly for a 135 or 133 or 137 ops. You'll also find some other countries allow it via a regulatory exemption. However, for your simple 91 ops under the FAA you find more guidance against it than for it. Even Robinson has a few docs out there against exiting the aircraft while running.
 
blueskyMD said:
There is reluctant approval by FAA
Click to expand...
FYI: FAA approval is very specific and defined. As mentioned above an FAA SAFO is not an approved document. Examples of FAA approval documents would be the FARs, ADs (which are amendments to Part39), TCDSs, AWCs, Orders, etc. Just because the FAA puts out a document doesn't mean the info is considered approved and can just be advisory in nature.
 
Helicopter crop sprayers reload their chemical tanks and hot-fuel all day long and we do not hear of any major issues .

Plenty of crackups and dangers in that industry but not related to fueling.

If I was in a remote location and had a marginal battery I would not hesitate hand pumping fuel from a barrel with the engine at idle.

I have a greater fear of dogs .... had a car-chasing type farm dog run at my tail rotor when I landed .... he took a playful nip at the spinning rotor and it killed him .... farmer was pretty good about it until he saw the damaged blade ($3800) and volunteered he had liability insurance to cover it
 
I remember as a kid watching crop dusters refuel with the engine running. Old bi-wings with radial engines and no other help to refuel.

I always thought it was funny that they refueled on their own, but had help refilling the hopper.
 
Plane isn’t nearly as bad as hanging on the side of a running heli
 
There’s a pipeline patroller that hot fuels an R44 at our airport quite frequently. I don’t remember the details about why, but I think it’s something like an hour that it must set after shutdown befor restart. He doesn’t, however, do it at the self serve pump although there’s probably not much difference. I’ve never paid attention to whether or not th is a pilot inside.
 
Last edited:
MBDiagMan said:
I think it’s something like an hour that it must set after shutdown befor restart.
Click to expand...
FYI: No. If that was required it would put a lot of people out of the Robbie helicopter business.
 
Zeldman said:
I remember as a kid watching crop dusters refuel with the engine running. Old bi-wings with radial engines and no other help to refuel.

I always thought it was funny that they refueled on their own, but had help refilling the hopper.
Click to expand...

Watched a one man spray operation in MN about 10 years back. He had a flatbed truck with a gas-tank and a big white poly chemical tank at the airport. Had a system down ro hot-load both at the same time. The S2 just idled while he filled the hopper and/or added fuel. Last thing before getting back in he would stage a chock in the correct position for the next round. A few gallons of Avgas was probably cheaper than paying ground crew.
 
Bell206 said:
FYI: No. If that was required it would put a lot of people out of the Robbie helicopter business.
Click to expand...

My guess is that it is because it takes a heck of a lot longer to shut down an R44 than it does to shut down almost any fixed-wing. You have to wait for CHT to drop, then you have to wait for the rotor to slow down, then you can apply the rotor brake to bring it to a stop. By the time you have done all that, you could have dumped ten gallons of fuel in the tank.
 
One thing about the Robinson helicopter is the extra tall mast which makes it safer for ground personnel .... however you need a stepladder to refuel which brings you up closer to the rotor .... and with 2 tanks you have to drag the hose and carry the stepladder to each side

Hughes 500 has a low rotor but fuel filler is down low on the right side of the fuselage ... you could almost do it on your knees ... tanks are under the cabin so any spills would not be close to the engine
 
Zeldman said:
Maybe the Robbie guys squirt water on the engine after shut down....:cool:
Click to expand...

post-14251-eddie-murphy-i-see-what-you-di-paqx-jpeg.22077


Uh oh, ...here we go again!:goofy:
 
Hmm

I’ve done the ag thing and I don’t like the idea of rolling up on a random airport and hot fueling 110LL alone in a helicopter. It could run sideways pretty easily and if it did there’s a lot unknown about other folks being around. Not a great idea but that’s just my personal risk assessment.
 
A Martin said:
One thing about the Robinson helicopter is the extra tall mast which makes it safer for ground personnel .... however you need a stepladder to refuel which brings you up closer to the rotor .... and with 2 tanks you have to drag the hose and carry the stepladder to each side

Hughes 500 has a low rotor but fuel filler is down low on the right side of the fuselage ... you could almost do it on your knees ... tanks are under the cabin so any spills would not be close to the engine
Click to expand...
This guy was just hanging off the side of the heli with one hand, and fueling with the other. Didn’t even bother with a ladder.
 
Tarheelpilot said:
Hmm

I’ve done the ag thing and I don’t like the idea of rolling up on a random airport and hot fueling 110LL alone in a helicopter. It could run sideways pretty easily and if it did there’s a lot unknown about other folks being around. Not a great idea but that’s just my personal risk assessment.
Click to expand...


My thinking exactly!

Even hand-propping my little "non-starter-equipped" airplane at an unfamiliar airport makes me nervous. I always imagine a group of POA experts gathered around to look out the window, tongues wagging and heads shaking as I single-handedly prop start my little airplane. I expect a visit from the FSDO any day.
 
Somewhat unrelated .... but one time at an airport (cold weather) the (Cub ? ) pilot was aggressively working the primer plunger on his dash prior to starting .... until fuel began dripping out from the bottom of his engine cowl ... it looked "dangerous" to me to have raw fuel in the engine compartment so I pointed it out to him but he waved me off .... must have known what he was doing because it started immediately .
 
A Martin said:
Somewhat unrelated .... but one time at an airport (cold weather) the (Cub ? ) pilot was aggressively working the primer plunger on his dash prior to starting .... until fuel began dripping out from the bottom of his engine cowl ... it looked "dangerous" to me to have raw fuel in the engine compartment so I pointed it out to him but he waved me off .... must have known what he was doing because it started immediately .
Click to expand...

I have an updraft carb on my little airplane. When I prime, I look for a few drops of fuel to come out the throat of the carb. Especially in cold weather, you'll see some airplanes do that. And, you wouldn't be the first person to stop and tell 'em they flooded it, only to watch it start right up on the 2nd or 3rd blade.
 
I have a friend in South Texas that has two R44s. He's always busy, chasing cattle on the King Ranch, netting deer, hog hunts, and quite a few other activities.

He says NFW he will hot fuel the birds by himself. He told me the factory friction lock is so unreliable he designed one and had a machinist friend build it. Even with that lock he feels the risk is too great, because many things can happen when hot fueling and they're almost all bad.
 
A Martin said:
Somewhat unrelated .... but one time at an airport (cold weather) the (Cub ? ) pilot was aggressively working the primer plunger on his dash prior to starting .... until fuel began dripping out from the bottom of his engine cowl ... it looked "dangerous" to me to have raw fuel in the engine compartment so I pointed it out to him but he waved me off .... must have known what he was doing because it started immediately .
Click to expand...

The only people who know how to start my engine/carb combo are the people who start my engine/carb combo. That being said, if you are new to little old airplanes I can see how you might be concerned.
 
Any plane with a carb with an accelerator pump will dump fuel like that. My Mooney does it. I don’t pump the throttle until after the prop is spinning to suck as much of the fuel into the cylinders as possible.
 
Zeldman said:
I remember as a kid watching crop dusters refuel with the engine running. Old bi-wings with radial engines and no other help to refuel.

I always thought it was funny that they refueled on their own, but had help refilling the hopper.
Click to expand...
i was just going to say this... i have seen crop dusters not only refuel, fill the hopper, but the pilot grabbing a quick dinner while that big arse radial engine turning with no one at the controls
 
You must log in or register to reply here.
Back
Top